OPEN ACCESS
Straw, as a fiber, has been used as part of building materials for several years. A carefully constructed straw-bale building has excellent thermal performance because of the combination of the high isolative value of the bales and the thermal mass provided by the thick plaster coating of the interiors. This paper addresses the thermal performance of rice straw bales and walls plastered with different cement plaster mixes. The plaster mixes are applied on straw bales of thickness 45 cm. A fire resistance test is conducted for two complete hours on the bales using direct flame after which the flame was discontinued. According to the test results, the mix with equal parts of cement and lime showed acceptable mechanical properties. This mix is chosen to be applied on a prototype straw bale wall compartment with an aim to evaluate the thermal performance of the plastered straw bale walls in arid desert climate at the hottest month of the year in Egypt. The straw bale wall test is undertaken by collecting actual measurements on site. Thermal sensors are installed on both external and internal sides of the wall to record the heat transmission through the plastered walls. The results showed that all the plastered bales survived fire penetration for the life period of the test. Increasing the lime content and decreasing the cement content of the mix raises the possibility of weak areas in the plaster of straw bale walls causing cracks during direct fire exposure. Similar width and density of the bales for all the speci-men mixes didn’t affect the heat transmission through the bales, which did not exceed 5.3°C in all samples. The site readings on the straw bale walls showed high range of temperature fluctuation on the external wall sensor, while in the internal wall sensor the temperature fluctuation was kept to minimum values. It was concluded that due to their high thermal insulation, straw bale structures require comparatively less energy to sustain thermal comfort conditions.
Exposure period, heat transmission, straw bale cement plaster mixes, thermal comfort, thermal performance
[1] Yu, J. & Changzhi, Y., Evaluation on energy and Thermal Performance for Residential Envelopes in Hot Summer and Cold Winter Zone of China. Applied Energy, 86(10), pp. 1970–1985, 2009. doi:10.1016/j.apenergy.2009.01.012
[2] Da Silva, V.D. & de Azevedo, P.V., Evaluating the Urban Climate of a Typically Tropical City of Northeastern Brazil. Environment Monitor Assessmment 2009 Jan 30. doi:10.1007/s10661-008-0726-3, 2009.
[3] Al-Homoud, M., Abdou, A. & Budaiwi, I., Assessment of monitored energy use and thermal comfort conditions in mosques in hot-humid climates. Energy and Buildings, 41(6), pp. 607–614, 2009. doi:10.1016/j.enbuild.2008.12.005
[4] http://www.africaguide.com/country/egypt/info.htm.
[5] Shebl, S., Effect of window to wall ratio and different climate conditions on energy consumption for residential and commercial buildings in Egypt. HBRC Journal, 3(2), pp. 115–126, 2007.
[6] Stone, N., Thermal performance of plastered straw bale walls (Chapter 7), Design of Straw Bale Buildings, ed. B. King, Green Building Press: California, pp. 185–194, 2006.
[7] Information Guide To Straw Bale Building, For Self Builders and the Construction Industry, Straw Bale Futures – Amazon nails 2001, www.strawbalefutures.org.uk.
[8] Theis, B., Straw bale Fire Safety: A review of testing and experience to date, July 30, 2003.
[9] Test Report prepared for Ecological Building Network, ASTM E 119-05a, Fire Tests of Building Construction and Materials, 2 HR fi re Resistance Test of a Non Load Bearing wheat straw bale wall, 2007.
[10] Garas, G., Allam, M. & Ragab, A., Towards Sustainable Waste Management Through Structural Testing of Rice Straw bale Cement Plasters, Waste Management and the Environment IV, Ecology and the Environment, vol. 109, ISBN: 978-1-84564-113-9, 2008.
[11] Garas, G., Allam, M., & Mamdouh, K., Straw Bale Fire Test on Cement Plaster Mixes, Print ISBN: 1-84564-193-1, Rome–Italy, 2009.